How to replace BMW E46 BLOWER MOTOR RESISTOR FSU final stage unit
Open the Glove box. Remove the three phillips screws across the top of the open box.
Remove the two phillip screws that are deeper in on the sides of the open box (nine and three o'clock).
Hard to see, use your flashlight.
With these screw removed remove the glove box. Disconnect the flashlight charger plug, and the glove box light connector.
Pay attention to the wire routing. Remove plastic cover behind glove box.
Locate motor and metal link to one of the a/c doors.
Remove the metal arm from the plastic clip. Slide motor out and disconnect.
There is an odd shaped black plastic piece with two T-20 or 25 Torx screws that need to be removed.
Remove plastic piece. The Final stage is located behind the metal arm for the a/c door.
Remove the floor heater duct for more room.
Remove heater duct careful not to break the blend air door cam (white) and the lever connected to it (black).
You can pull that black lever out if you are patient.
Back to the final stage now that you have more room. It is the component with the 5 0r 6 large gauge wires on the connector.
Push back the black plastic clamp while pulling/wiggling on the connector.
The final stage should come out, then disconnect the connector.
Reinstall all. Make sure the heater duct is installed properly if you removed it.
Good Luck !
If you found this video helpful
Your donation will help poor children in South America,
Thank you !
Find Deals Prices & Stores
|
|
Subscribe to:
Post Comments (Atom)
6 comments:
I have a quick question for you if I may? Are you still maintaining this blog? Thanks, Bo
hi change it and follow all your instructions but still not work?
This is a very thorough article. Thank you for sharing this information.
BMW Repair Dallas
I admire the valuable information you offer in your articles. I will bookmark your site!!
Auto Body Repair
Please delete spam comment by Jems Nichole with link pointing at my auto repair site. Thank you for your time! contact me to comfirm if you need to - info@ linearautomotive repair dot com
Please delete spam comment by Veronica Jett with link pointing to my auto repair website. Thank You !!
Post a Comment